|
S80 '98-'06 / S60 '00-'09 / V70 & XC70 '00-'07 General Forum for the P2-platform S60 / V70 / XC70 / S80 models |
Information |
|
"Engine System Service Required" + Orange triangleViews : 2083 Replies : 41Users Viewing This Thread : |
|
Thread Tools | Display Modes |
Apr 20th, 2024, 17:28 | #1 |
New Member
Last Online: Jun 23rd, 2024 13:08
Join Date: Nov 2023
Location: Quito
|
"Engine System Service Required" + Orange triangle
Hello!
I am going to purchase a 2003 V70 2.4 NA 140 hp. It has "Engine System Service Required" + Orange triangle warning, and car is in limp mode. That happened when the owner started the car with a booster because the battery is dead. Owner thinks it is a bad ignition coil (a year ago did the same with two bad ignitions coils, only replaced that two). He can't read DTCs. He is from a forum where I write too (not Volvo) and I trust him. The problem is I am about 400 miles away. Price is very good. My insurance will not tow the car if the technical inspection is out of date (Yes, it is out of date). So my plan is take a train with 5 ignition coils and spark plugs, VIDA and some other spare sensors I have at home. What do you think guys? If I can't take out from the limp mode and drive to my home it would be perfect. Any suggestion are welcomed. Last edited by r0ber; Apr 20th, 2024 at 17:34. |
Apr 20th, 2024, 17:55 | #2 |
Senior Member
Last Online: Yesterday 20:49
Join Date: Aug 2006
Location: Cannington
|
It could just be the low voltage that has caused it.
Last time I left the ignition on on ours about a year ago, and had to jump start it, it threw an absolute fit - every warning message you could think of. Engine, gearbox, ABS etc. And the electric seats lay themselves down, which was entertaining. After TWO rounds of clearing errors in VIDA its been fine since. You might get lucky! If the battery is 'dead dead' you'll need a fresh one. |
Apr 20th, 2024, 19:07 | #3 | |
New Member
Last Online: Jun 23rd, 2024 13:08
Join Date: Nov 2023
Location: Quito
|
Quote:
Yeah, last night I was reading a lot of info (maybe too much) and somewhere I read what you said. Lets see if I am lucky About battery: I sending a new one to the owners home to change in first place. Besides that the car has half tank of two years old gas... |
|
Apr 20th, 2024, 19:49 | #4 |
Premier Member
Last Online: Yesterday 18:58
Join Date: Feb 2009
Location: Hackensack
|
Bring some hose and a vessel and syphon some out and inspect. Lots of people's "vehicle resurrection" stories fear the old gas. Many are told not to fret.
Also, I don't see any "old fuel ruined my day" posts. If the car buffs have a time dead line for fuel age, I haven't heard it. Is there electricity there? for a small compressor. Check oil level before an 8 hour drive. Raining? Check for washer fluid and blade function. A filthy smeary windshield can kill you on a long drive. Search MM throttle body for the story about the ETM. In brief: A bad ETM is removed (easy) and sent to a place for rebuilding, as your own ETM is coded to the car. If the accelerator reacts funny or if the engine 'hunts' at idle, you got a worn one. No problem to drive home. Check the instrument cluster for chrome rings...... |
Apr 20th, 2024, 20:18 | #5 |
just trying to be helpful
Last Online: Today 00:26
Join Date: Aug 2020
Location: Dagenham
|
stale fuel is mentioned from time to time over on the mini forum but bear in mind of course some of those are 30-40-50-60 year old cars
and they do say, the old ones with simple breathers to the atmosphere (old carb models) suffer more than the 'sealed' mpi / spi models of more recent times I guess it's about whether air and therefore moisture has got in, and then they go on about modern fuels being worse for moisture and so on I'm sure if you turn up with VIDA under one arm and a fully charged battery you can't go too far wrong Last edited by stuart bowes; Apr 20th, 2024 at 20:20. |
Apr 21st, 2024, 16:25 | #6 | ||
New Member
Last Online: Jun 23rd, 2024 13:08
Join Date: Nov 2023
Location: Quito
|
Quote:
I have read about the MM. If I no mistaken my 2000 V70 2.4T have one but I am lucky until today What it is the thing about the "chrome rings"? Thank you for your help! Quote:
Seller is going to charge the battery (is one year old, I thought it was older but not. Just he does not use de the car) and if it is definitely dead I will buy one there. Thank you guys. |
||
Apr 21st, 2024, 16:57 | #7 |
Premier Member
Last Online: Yesterday 21:32
Join Date: Mar 2017
Location: Manchester
|
[QUOTE=r0ber;2946397]Hello!
I am going to purchase a 2003 V70 2.4 NA 140 hp. It has "Engine System Service Required" + Orange triangle warning, and car is in limp mode. That happened when the owner started the car with a booster because the battery is dead. Owner thinks it is a bad ignition coil (a year ago did the same with two bad ignitions coils, only replaced that two). He can't read DTCs. He is from a forum where I write too (not Volvo) and I trust him. The problem is I am about 400 miles away. Price is very good. My insurance will not tow the car if the technical inspection is out of date (Yes, it is out of date). So my plan is take a train with 5 ignition coils and spark plugs, VIDA and some other spare sensors I have at home. What do you think guys? If I can't take out from the limp mode and drive to my home it would be perfect. Any suggestion are welcomed.[/QUOTE a good battery is a must have before attempting to read any codes remember to read off the delivery tab as these are the current codes initial state tells what codes have been stored previously then you can act accordingly replacing any part which may have caused the limp mode good luck i hope all goes well |
Apr 28th, 2024, 07:46 | #8 | ||||
New Member
Last Online: Jun 23rd, 2024 13:08
Join Date: Nov 2023
Location: Quito
|
Quote:
Quote:
Quote:
Quote:
Successful mission!! Thank you guys! So... I took some tools, wife and went by train 600 kms away for pick up the 2003 V70 2.4 140 hp. Car was showing Engine System Service Required + Orange triangle warning, and was in limp mode. As the seller suspected a bad ignition coil could be the cause. And yes, the misfire was in the cylinder 2. I replaced the 5 ingnition coils and spark plugs (Amazon, I ordered there because I need very fast the parts) but one of the was another model with bigger head: 18 mm, 19 mm... instead the 16 mm. I saw after put it and turn with the rubber of the tool. My wife had to look for pliers in some shop. Luckily I could remove it, and reinstall an old one. Ok, and this point limp mode was gone. Still have Engine System Service Required + Orange triangle warning and DTC ECM-930C Clutch Position Sensor - Faulty signal. Put some 98 octane gas for mix with the old 95 and made a 30 kms road test. Everything was fine except Cruise control (VIDA says because ECM-930C Clutch Position Sensor - Faulty signal) and the lack of power compared with my 2.4T stage 1 Ah, seller told me we was going to recharge battery when I said I wanted to buy a new one. I was one year old and didn't know if It was really dead. Looks it is fine (finger crossed) After the test drive I was happy We went to visit the city and next day leave driving the Volvo. Yesterday, already at home, I fixed the Clutch Position Sensor with a resistor as I saw here: https://www.youtube.com/watch?v=PjnPWieNtM4 So... I was lucky. Everything was fine! THANK YOU GUYS! |
||||
May 3rd, 2024, 18:14 | #9 |
New Member
Last Online: May 3rd, 2024 19:28
Join Date: May 2024
Location: OVD
|
XC70 with similar issue.
Hi guys,
I am going to hijack this one since I have a similar problem. I have a 2007 XC70 D5 Manual 345k. Runs fine and has had most things done. I installed a new radio which required me to disconnect the Climate control and also had a pending service light from a service which was done 5k ago. I have gotten a version of VIDA and a Mountgoose reader to reset both codes which worked like a dream. Issue is now and I dont know if the are related, that I have the same issue like the car in this pose. I get a error message saying 'System Motor Revison needed' and the car seems to be in limp mode. (no turbo can be felt) From the VIDA I have the attached Error message from the turbo but not sure if it just needs a few VIDA wipes or if something else is actually wrong. Image here: The other units on the bus with errors are a internal airsensor which is faulty and the steering audio control which is disconnected nothing really bad. so is this reset I did trigger something with the turbo or is this just luck? |
May 3rd, 2024, 22:08 | #10 |
Premier Member
Last Online: Yesterday 21:32
Join Date: Mar 2017
Location: Manchester
|
this car has had this fault a long time it states 567 times /cycles i would guess this car has been remapped look at the ecm with the advanced tab after entering vehicle communications to see further into the problem. read modules that show faults
|
The Following User Says Thank You to Simmy For This Useful Post: |
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests) | |
|
|